MSDS Sheet

MSDS

Lubricut

Section I

Manufacturer's name: Weiler Corporation
Address: One Weiler Drive, Cresco, PA 18326
Emergency telephone number: (570) 595-7495
Telephone number for information: (570) 595-7495
Date prepared: January 25, 2006
Name of preparer: Frank J. Hettes

Section II - Hazardous Ingredients / Identity Information

This product contains no chemicals subject to the reporting requirements of OSHA's Hazard Communication Standard 29 CFR 1910.1200. All components in this product are listed on TSCA.

Section III - Physical / Chemical Characteristics

Boiling Point: >400F
Vapor Pressure (mm Hg.): NA
Vapor Density (AIR=1): >1
Specific Gravity (H₂O=1): 0.92
Melting Point: NA
Evaporation Rate (Butyl Acetate=1): <1
Solubility in Water: Insoluble
Appearance and Odor: Blue viscous fluid with mild odor

Section IV - Fire and Explosion Hazard Data

Flash Point (method used): 608F
Flammable Limits: LEL: NA UEL: NA
Extinguishing Media: Water = No; CO2 = Yes; Dry Chemical = Yes; Foam = Yes; Alcohol Foam = No
Special Fire Fighting Procedures: Firefighters should wear self-contained breathing apparatus in confined areas.
Unusual Fire and Explosion Hazards: None

Section V - Reactivity Data

Stability: Stable
Conditions to Avoid: None
Incompatibility (Materials to Avoid): Strong oxidizing agents

Hazardous Decomposition or By-products: Oxides of Carbon

Hazardous Polymerization: Will not occur.
Conditions to Avoid: None.

Section VI - Health Hazard Data

Inhalation Health Risks and Symptoms of Exposure: Unlikely at normal room temperatures.
Skin & Eye Contact Health Risks and Symptoms of Exposure: None
Skin Absorption Health Risks and Symptoms of Exposure: None
Ingestion Health Risks and Symptoms of Exposure: None
Health Hazards (Acute & Chronic): None
Carcinogenicity: NTP? No IARC Monographs? No
OSHA Regulated? No ACGIH? No
Medical Conditions Generally Aggravated by Exposure: None

Emergency and First Aid Procedures:
Eyes: Flush well with water
Skin: Wash with soap & water
Inhalation: No emergency care anticipated under normal conditions
Ingestion: Do not induce vomiting. Contact a physician. If vomiting occurs, keep head below hips to prevent aspiration of liquid into lungs.

Section VII - Precautions For Safe Handling And Use

Steps to be taken in case material is released or spilled: Mop up or use absorbent material; wash area; discard in suitable containers.

Waste disposal method: Remove to a waste disposal facility operating in compliance with federal, state and local regulations.

Precautions to be taken in handling and storing: If mists are generated, the following values reflect the established exposure levels for organic/natural oils:
ACHIG - TLV/TWA = 10mg/m3/8hr
OSHA - PEL/TWA = 10mg/m3/8hr
ACGIH - TLV/STEL = 10mg/m3

Section VIII - Control Measures

Respiratory protection (specify type): None required at normal handling temperatures.

Ventilation:
Local exhaust: Recommended for confined areas
Special: None
Mechanical (General): General mechanical ventilation is adequate for normal use.

Protective gloves: None

Eye protection: None

Other protective clothing or equipment: None required under normal use

Work/Hygienic Practices: Follow current H.M.I.S. regulations

Section IX - Regulatory Information

Non-Hazardous Substance - as defined by U.S. Department of Transportation and U.S. Coast Guard; CFR - Title 49 (Transportation), Chapter 1, Section 172, paragraph 101.

U.S. Department of Labor/Occupational Safety & Health Administration - CFR - Title 29 (Labor), Chapter XVII, Section 1910, paragraph 1200.

Non-Carcinogenic or Mutagenetic as defined by IARC (International Association for Research on Carcinogens) and NTP (National Toxicology Program) Third Annual Report.

Not subject to chemical release reporting as defined by U.S. Environmental Protection Agency Title III (Emergency Planning and Community Right to Know Act), Section 313 of SARA (Superfund Amendment and Reauthorization Act).

Non-toxic as defined by FHSA (Federal Hazardous Substance Act)/U.S. Food and Drug Administration

Section X - Disclaimer

Weiler Corporation bases the information and recommendations in this document on data believed to be correct. No warranty of any kind, however, is made as to the information in this document.

*N/A = Not applicable

MSDS Lubricut

MSDS

Lubricut