MSDS

Vitrified Bond Grinding Wheels & Mounted Points

Section I

Manufacturer's Name: Weiler Corporation
Address: One Weiler Drive, Cresco, PA 18326
Emergency Telephone Number: (570) 595-7495
Telephone Number for Information: (570) 595-7495
Date prepared: January 25, 2006
Name of preparer: Frank J. Hettes

Section II - Hazardous Ingredients / Identity Information

Hazardous Components,
(Specific Chemical Identity, Common Name(s)

CAS#

OSHA PEL

% *REG.
(Y/N)

ACGIH
TL

Carcinogen
(Y/N)

% (optional)

Alpha Alumina (Aluminum Oxide)
AL2O3

1344-28-1

15mg/m3

Y

10 mg/m3

N

99%

Total Impurities
(CaO + Fe2O3 + MgO + Na2O + SiO2 + TiO2)

1344-28-1

15mg/m3

Y

10mg/m3

N

1%

Section III - Physical / Chemical Characteristics

Boiling Point: N/A
Vapor Pressure (mm Hg.): NAIF
Vapor Density (AIR=1): N/A
Percent Volatile by Volume: NAIF
Solubility in Water: Insoluble
Solubility in Alcohol: Insoluble
Solubility in Other Solvent: NAIF
Specific Gravity (H2O=1): 4.6
Melting Point: 2072°C
Evaporation Rate (Butyl Acetate=1): NAIF
Appearance and Odor:

Section IV - Fire and Explosion Hazard Data

Flash Point (method used): N/A
Flammable Limits: NAIF    LEL:   UEL:
Extinguishing Media: NAIF
Special Fire Fighting Procedures: None
Unusual Fire and Explosion Hazards: None

Section V - Reactivity Data

Stability: Stable
Conditions to avoid: NAIF
Incompatibility (Materials to Avoid): NAIF
Hazardous Decomposition or Byproducts: NAIF
Hazardous Polymerization: Will not occur
Conditions to avoid: NAIF

Section VI - Health Hazard Data

Primary Route(s) of Entry Acute and Chronic Health Effects and Effects of Overexposure First Aid and
Medical Information
Inhalation
(during use)
(dust) 		Acute: May cause coughing, shortness of breath. Chronic: May effect breathing capacity. Remove to fresh air. Apply artificial respiration as needed; obtain first aid or medical assistance.
Ingestion
 No known adverse affects, but ingestion is not recommended. Obtain first aid or medical assistance, if needed.
Skin (contact
& absorption)		 Not absorbed through skin; may cause abrasions. Obtain first aid or medical assistance, if needed.
Eye
(dust) 		May irritate eyes. Wash with large amounts of water, obtain first aid or medical assistance, if needed.
Other Potential
Health Risks
 None known. -

Section VII - Precautions For Safe Handling And Use

Normal Storage and Handling: Handle with adequate ventilation. See OSHA 29CFR1910.94 (Ventilation)
  and OSHA 29CFR1910.1000 (Air Contaminants).
Normal Use: Handle with adequate ventilation for nuisance dust. See OSHA 29CFR1910.94 (Ventilation)
  and OSHA 29CFR1910.1000 (Air Contaminants).
Precautions to be taken in handling and storage: None
Steps to be taken in case material is released or spilled: Normal clean up procedures. Respirators may be required.
Waste disposal method: Standard landfill methods consistent with applicable federal, state and local laws.

Section VIII - Control Measures

Respiratory protection (specify type): As needed, approved dust respirator. See OSHA 29CFR1910.134.
Ventilation:
  Local Exhaust: Recommended
  Mechanical (General): Recommended
  Other: NAIF
Protective gloves: As desired by user
Eye protection: Recommended - see OSHA 29CFR1910.122
Other protective clothing or equipment: NAIF

NAIF = No applicable information found
N/A = Not applicable

Weiler Corporation Home
About Us | Products | Where To Buy | Solutions | Resources | Vortec Pro | Site Map

E-mail: info@weilercorp.com | Phone: 570-595-7495 or 800-835-9999


All Rights Reserved, Copyright © Weiler Corporation 1998-2008